Sharp aquos lc-46d85u Service manual with schematics

Collapse
X
Collapse
+ More Options
Posts
 
  • Time
  • Show
Clear All
new posts
  • drkthundr
    Member
    • Feb 2016
    • 45
    • United States

    #21
    Re: Sharp aquos lc-46d85u Service manual with schematics

    Could I do something like this YouTube video shows to test for normal voltages at all the pins if the board thinks it is getting the proper voltage to the ps_on pin? Thought I would get your input. https://youtu.be/mUvclBfaMXg

    Comment

    • budm
      Badcaps Legend
      • Feb 2010
      • 40746
      • USA

      #22
      Re: Sharp aquos lc-46d85u Service manual with schematics

      You can do the force on using 470~1K RESISTOR (I will never do direct connection between the STBY and PS-ON pin) with the connector still in place but you must remove the PS-ON wire going back to the main board first.
      Or you can test the main board by itself out side the TV chassis as shown in the Video but still use the resistor.
      Never stop learning
      Basic LCD TV and Monitor troubleshooting guides.
      http://www.badcaps.net/forum/showthr...956#post305956

      Voltage Regulator (LDO) testing:
      http://www.badcaps.net/forum/showthr...999#post300999

      Inverter testing using old CFL:
      http://www.badcaps.net/forum/showthr...er+testing+cfl

      Tear down pictures : Hit the ">" Show Albums and stories" on the left side
      http://s807.photobucket.com/user/budm/library/

      TV Factory reset codes listing:
      http://www.badcaps.net/forum/showthread.php?t=24809

      Comment

      • drkthundr
        Member
        • Feb 2016
        • 45
        • United States

        #23
        Re: Sharp aquos lc-46d85u Service manual with schematics

        I was going to leave it mounted in the TV disconnect all the cables from the connectors and jumper it with the resistor like you suggested. I'm guessing the standby voltage is the 5 volt pin on the pd connector.

        5v - resistor - ps_on

        Comment

        • drkthundr
          Member
          • Feb 2016
          • 45
          • United States

          #24
          Re: Sharp aquos lc-46d85u Service manual with schematics

          Guess I will have to put the testing off until sometime during the week. Can't find a resistor in the right range Either have resistors way to high or extremely to low. Will post results when able.
          Last edited by drkthundr; 02-13-2016, 05:12 PM.

          Comment

          • drkthundr
            Member
            • Feb 2016
            • 45
            • United States

            #25
            Re: Sharp aquos lc-46d85u Service manual with schematics

            OK here are the reading of all connections with 5v standby and ps_on jumpered with the resistor.
            Attached Files

            Comment

            • drkthundr
              Member
              • Feb 2016
              • 45
              • United States

              #26
              Re: Sharp aquos lc-46d85u Service manual with schematics

              On So far i have found a bad transistor at q7152 on the power board. Not sure if this the part causing my issue or if there are more parts involved. Still searching.

              Comment

              • drkthundr
                Member
                • Feb 2016
                • 45
                • United States

                #27
                Re: Sharp aquos lc-46d85u Service manual with schematics

                [QUOTE=drkthundr;641038]On So far i have found a bad transistor at q7152 on the power board. Not sure if this the part causing my issue or if there are more parts involved. Still searching.[/QUOTE
                I tested it wrong q7152 is working correctly.

                Comment

                • drkthundr
                  Member
                  • Feb 2016
                  • 45
                  • United States

                  #28
                  Re: Sharp aquos lc-46d85u Service manual with schematics

                  Repair update:
                  I've not been well for a while so I put the TV on the back-burners for a while. So the tv would not power on but had a flashing power light and opc light. The power light and the opc lights where green in color and flashing the code 2 power 1 opc. For a while I thought i was dealing with a power board problem. I would get certain voltage you saw in earlier post but not the voltages that would allow the main board to turn on the power board. I final read some post on the internet about unplugging other boards on the tv to see if one of them was causing the issue. I started with the tcon board which had not affect. No voltages where i needed them. Next was the inverter board. Once I unplugged the inverter board my 13v and 60v where now where they needed to be. Because without that board being connected it allowed the main board to turn the power board on. So i looked at the master and the slave inverter board. The slave board was testing fine when checking the components. The master was another issue. I discovered 2 bad mosfets. Mos7502A (18N20Gl 841310) and Mos7501A (30P10Gi 835980). Every other component on board seem to test fine. I looked up the parts on the internet and could not find a match for them. I decided to buy an working board off of eBay to repair TV. TV is now working with no problems. Just thought I would update my post so if anyone else has the same flashing codes of the same TV it will give them an idea of where to look.

                  Comment

                  • R_J
                    Badcaps Legend
                    • Jun 2012
                    • 9516
                    • Canada

                    #29
                    Re: Sharp aquos lc-46d85u Service manual with schematics

                    If you want to repair the board I believe these should work: digikey RSD130P10TL and FDD18N20LZ

                    Comment

                    • drkthundr
                      Member
                      • Feb 2016
                      • 45
                      • United States

                      #30
                      Re: Sharp aquos lc-46d85u Service manual with schematics

                      Thanks for the information.

                      Comment

                      • drkthundr
                        Member
                        • Feb 2016
                        • 45
                        • United States

                        #31
                        Re: Sharp aquos lc-46d85u Service manual with schematics

                        Have a new problem that did not show up during my testing. After the TV has been on for a while the TV will shut off on its own. There is no standby light and the buttons are unresponsive. Even unplugging and plugging back in has no effect. Any ideas? I've not taken the cover back of yet. Sounds like something that is getting flakey when it gets to hot.

                        Comment

                        • drkthundr
                          Member
                          • Feb 2016
                          • 45
                          • United States

                          #32
                          Re: Sharp aquos lc-46d85u Service manual with schematics


                          Update: The tv was having an issue where after the tv was on for a while the tv would shut off, became unresponsive, and had no standby light. I suspected the power supply was causing the problem but that was not the case. the problem ended up being the PD cable that ran from the power board to the main board. I discovered it when i was checking around the main board and moved the harness connector and the tv shut off when i moved it some more the tv came back on. Took each wire out soldered the connector where it met the wire and now the tv is fixed. Now for A long testing period to make sure no other issues.

                          Comment

                          • leoelectronic1988
                            New Member
                            • Feb 2022
                            • 2
                            • Venezuela

                            #33
                            Re: Sharp aquos lc-46d65u Service manual with schematics

                            Hello friends I need help with this TV SHARP lc-46d65u which had problems with the source, after repairing said source the tv throws the following error code
                            LED_POWER and LED_OCP blink 1 time then LED_POWER twice
                            Thanks

                            Comment

                            Related Topics

                            Collapse

                            • Ritchie_Uk
                              Sharp 32BC2K0 Service Manual of Fix Please?
                              by Ritchie_Uk
                              Hi Folks

                              I am searching for a Sharp 32BC2K0 Service Manual
                              Sharp 32BC2K0 << Could be an "O" as in Orange or a Zero

                              Fault - Coloured "Bars" very thin all across the screen.
                              I would like tho get the values for the 2 Resistors and I believe a Missing Capacitor.

                              I would Like a Service Manual, that has the component values, and locations, as the PCB isnt that clear as for designations
                              Is there such thing as a Boardview for this TV?

                              I will Post the Photos in a second

                              Thanks
                              Stay Safe !...
                              09-05-2024, 06:35 AM
                            • Document Archive
                              LCD LED TV Service Menu Codes
                              by Document Archive
                              ALL LCD LED TV SERVICE MENU CODES

                              Service Menu Code with Board Name

                              China Universal Board / Jumper Board Service Menu Code
                              Changhong Ruba Service Menu Code
                              Ecostar LED TV Service Menu Code
                              Orient LED TV Service Menu Code
                              Haier LED TV Service Menu Code
                              TCL LED TV Service Menu Code
                              Samsung LED TV Service Menu Code
                              LG LED TV Service Menu Code
                              Videocon LED TV Service Menu Code
                              Supra LED TV Service Menu Code
                              Toshiba LED TV Service Menu Code
                              Symphony LED TV Service Menu Code
                              Veste/ LED TV Service Menu Code...
                              10-31-2024, 03:58 AM
                            • Youness
                              Clevo NV40MZ-NV41MZ service manual + schematic
                              by Youness
                              Hi All,

                              I'm sharing the Clevo NV40MZ-NV41MZ service manual including schematics (at the end of the document)

                              ​enjoy!!!!...
                              05-12-2025, 05:56 AM
                            • scubacamper
                              Sharp Aquos LC-70C6400U Half Screen Dark
                              by scubacamper
                              I found another post on this site the other day which has been very helpful in troubleshooting this issue I am having with my tv. The left half of the screen is dark, and the other half is VERY slow to generate it's image - and it only generates part of its image at that.
                              Based on this yt video, I have narrowed it down to an issue (short?) on the left side of the display, somewhere in the system of ribbon cables.
                              when I remove the bezel and the rear cover, I can get the image to display correctly by manipulating the ribbon cables on the left side which connects the left lower display...
                              05-03-2025, 12:19 PM
                            • mscottdoran@gmail.com
                              Realistic 31-1975A Receiver service manual
                              by mscottdoran@gmail.com
                              Hi, I’m looking for the service manual or schematic for a Realistic 31-1975A Stereo Receiver. If anyone has a PDF they could post I would greatly appreciate it. Thanks
                              02-13-2025, 01:56 PM
                            • Loading...
                            • No more items.
                            Working...