Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

[budm]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

https://www.badcaps.net/forum/attach...6&d=1521736034
Those prts in that section are for the Gate drive circuits, they are connected between the Gate drive out of the IC and the Gate pin of the MOSFET, when MOSFET shorted out between Gate and Drain, that will dump 160VDC ~380VDC to the output of the IC via those parts so they blew up.
Look up the P/N of the PFC IC spec. sheet, it will have some reference circuit that shows you how it is being used.

[Louis82]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

So you think the PFC IC is what it damaged my diodes. Because after I replaced the MOSFETs, I plugged in the board and the Mosfets remain doing fine, no short.

[budm]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

So you had problem in the PFC Voltage booster section, more likely the PFC IC got damaged when the PFC MOSFET went bad, I always replace the IC at the same time as the MOSFET since you can damage the new MOSFET if the IC is bad.
BTW, the part designator with 'P' indicates part related to PFC circuit: I.E. QP802

[Louis82]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

The blue dot is a 4.7 ohm that I found burned.
Red dots are the ZH and ZG diodes.
Yellow is a 10kohm resistir that test good but looked a little bit up so I removed it to replace it anyway.

Wonder if the DP807 diode I put in was bad (ordered from AliExpress) and it actually caused a worse mess.

As I said initially it was just the QP802, DP807, QP801 RP829, RP831 bad.

[budm]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

So whcih section of the board where those parts are bad?
PFC, LED driver, main supply, standby supply?

http://www.shopjimmy.com/samsung-bn4...led-board.htm#
Pictures provided by shopjimmy.

[Louis82]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Thanks for the SMD Code Book gents - Still wondering if the numbers written vertically mean anything. I been going through my scrap boards and I have found ZH diodes but they also show 1F, 1H written vertically. Thoughts?

@chrismurphy - Yes, It test shorted from pin top vs any of the two bottom. I removed them from circuit board an they seems to be bad.

@budm - Blown AC fuse. Found 2 mosfet, a transistor-diode and 2 SMD resistors shorted. Replaced all, tried again and now transistor-diode blew again plus a resistor (which it was probably bad from the beginning and I just missed it at first), and the 2 ZH diodes.

I will post pictures by noon. Seriously the board is very cheap, like $25 on eBay, but I already spent a good time messing with this and I want to find the problem - Challenged.

[budm]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Hi there,
I'm working on repairing the power board for this TV UN55JU7100.
Power Board part number is BN44-00811A. I have found two diodes shorted but not sure how to order a replacement. Can you guys help me understanding this part number. I wrote it down as camera can't focus well on this smd diode.

Something like: ZH 0H (shows written vertically)
See pic

What is wrong with the power board? Pictures?

[chrismurphy]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

[QUOTE=Louis82;813721]Hi there,
I have found two diodes shorted but not sure how to order a replacement. Can you guys help me understanding this part number. I wrote it down as camera can't focus well on this smd diode.

Are you sure the diodes are shorted
The 2 legs at the bottom are common and will show a short , the diode is between the top pin and any of the bottom pins

[Andrew F. Ali]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Oh yes!!...This is really good...Thank you very much for sharing....

[vinceroger69]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Thanks....This is a very useful book to have.

I also have this one if its any use

[Andrew F. Ali]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

this is a link to the smd code book it may help you find these

Thanks....This is a very useful book to have.

[nomoresonys]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Hello, I'm new to this forum to address my issue I've had with my tv for quite a while now and its getting very frustrating when it starts happening!
Im having like a flickering type of noise in the middle of my tv (horizontal) it happens randomly, mainly when alot of use is put into the tv at once, like if i play a game or watch a movie it happens more when the tv has been ON.

I've had the panel, and mainboard replaced by samsung... i am now out of warranty.. my options are limited the only thing they didn't replace was the PSU"PowerSupply" and I've done some research and there was 1 person on youtube that had same issue and mentioned PSU, but i don't know. id like to get more opinions! which is why i am here... all help would be appriciated..
also i don't know if interference can cause this as i have many electronics, including my router and modem on my one dresser where my tv hangs above.

thanks all,

kind regards.

Easy test, just unhook/turn off everything but the tv, to see if it's electronic interference.

[vinceroger69]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

this is a link to the smd code book it may help you find these

[Louis82]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

I found another shorted: ZG 0F

Thanks in advance!

[Louis82]

Re: Need help with my Samsung UN55JU7500 random "flickering" in the middle of the tv

Hi there,
I'm working on repairing the power board for this TV UN55JU7100.
Power Board part number is BN44-00811A. I have found two diodes shorted but not sure how to order a replacement. Can you guys help me understanding this part number. I wrote it down as camera can't focus well on this smd diode.

Something like: ZH 0H (shows written vertically)
See pic

[FallinDeep]

Hello, I'm new to this forum to address my issue I've had with my tv for quite a while now and its getting very frustrating when it starts happening!
Im having like a flickering type of noise in the middle of my tv (horizontal) it happens randomly, mainly when alot of use is put into the tv at once, like if i play a game or watch a movie it happens more when the tv has been ON.

I've had the panel, and mainboard replaced by samsung... i am now out of warranty.. my options are limited the only thing they didn't replace was the PSU"PowerSupply" and I've done some research and there was 1 person on youtube that had same issue and mentioned PSU, but i don't know. id like to get more opinions! which is why i am here... all help would be appriciated..
also i don't know if interference can cause this as i have many electronics, including my router and modem on my one dresser where my tv hangs above.

thanks all,

kind regards.