Battery Charging Peugot Boxer

Collapse
X
 
  • Time
  • Show
Clear All
new posts
  • barry wilkins
    Senior Member
    • Aug 2009
    • 172

    #1

    Battery Charging Peugot Boxer

    I am having a problem with the starter battery in my motor caravan, the makers info is very poor so I am struggling a bit with this.
    As it is Euro 6 I think the charging is done by the ECU,not the spilt charge system with relays.
    I managed to start the engine after a boost and the voltage rose to about 14 volts ,but now it is about 11.5 volts.
    It is not charging by the EHU where the 12volt power supply is.
    It is quite complex .
    Starter battery
    Liesure battery
    Solar panel
    BCA module with relays fuses and the power supply
    The fuse in the manual that is shown to charge the battery is not connected to the battery?
    The lead I think is to charge the battery goes somewhere and I think it goes to the computer.
    On the liesure battery there are 2 black leads wihich must go to the chassis,and 2 red leads one definitely goes to the relay panel ,the other one dissapears some where ,I think this going to land up some in the engine compartment.
    Any body got expirence on this subject ?

    Thanks

    Barry Wilkins
  • sam_sam_sam
    Badcaps Legend
    • Jul 2011
    • 6024
    • USA

    #2
    Re: Battery Charging Peugot Boxer

    First thing you need is the wiring diagram for the model number and year of this Peugot Boxer before you can really troubleshoot the problem

    If you can find the wiring diagram for it and can post it I might be able to to help you with it

    Comment

    • petehall347
      Badcaps Legend
      • Jan 2015
      • 4423
      • United Kingdom

      #3
      Re: Battery Charging Peugot Boxer

      remove batteries and charge them then have them tested

      Comment

      • barry wilkins
        Senior Member
        • Aug 2009
        • 172

        #4
        Re: Battery Charging Peugot Boxer

        Got to the bottom of it.
        A fuse in the power feed from the battery,no mention of it anywhere.

        Barry
        Attached Files

        Comment

        • redwire
          Badcaps Legend
          • Dec 2010
          • 3900
          • Canada

          #5
          Re: Battery Charging Peugot Boxer

          The fuse was blown?

          I've read there is a red button near the ignition switch to disconnect the battery (-) in the event the vehicle is sitting in storage.

          Comment

          • petehall347
            Badcaps Legend
            • Jan 2015
            • 4423
            • United Kingdom

            #6
            Re: Battery Charging Peugot Boxer

            Originally posted by barry wilkins
            Got to the bottom of it.
            A fuse in the power feed from the battery,no mention of it anywhere.

            Barry
            those wires have been added

            Comment

            • barry wilkins
              Senior Member
              • Aug 2009
              • 172

              #7
              Re: Battery Charging Peugot Boxer

              It was a poor conection.
              Yes the van has a Tyco isolator relay that disconnects most of the electronics to stop the battery discharging.
              I understand this is a bistable relay
              My old van was a Ducato ,I fitted a 100A switch in the lead from the battery to the fuse box to stop thuis from happening.
              Barry

              Comment

              Related Topics

              Collapse

              • Bowline
                Dell E6400 PT434 type Battery Charging Stuck at 1%. Battery Pinouts?
                by Bowline
                My question pertains to understanding the control circuity inside a Dell PT434 type battery used in Dell E6400, E6410 and other Dell notebooks?

                Does anyone have a circuit diagram for the inside of a Dell PT434 battery and/or a description of how the control lines work to control this battery?

                My reason for asking is I have a battery which I cannot get to charge beyond 1% in a Dell E6410 or E6400.
                The LED bar graph charge indicator on the battery shows one LED lighted when the info button is pressed.
                I have tried multiple different Dell power adapters. My Dell...
                06-11-2025, 10:13 AM
              • Julian Bailey
                HP ProBook 445 G8 Battery not charging
                by Julian Bailey
                Hi all

                We have in a HP ProBook 445 G8 laptop with AMD Ryzen 7 CPU. When power is connected the power LED light blinks 5 times then stops. Normally HP laptops will blink this LED 10 times as it does a self test when the AC adaptor is inserted. So there must be some sort of short somewhere.

                The battery doesn't charge, and is erratic on the MM voltage. Bench PSU LED pulsates when the battery is connected also. So the fault must be on the charging circuit?

                I have gone around the board with a MM and cant find anything

                Windows shows the battery fine,...
                10-11-2024, 10:34 AM
              • piernov
                Laptop battery charging circuit
                by piernov
                1. Some theory
                1.1. Introduction
                Almost every laptop has a charging circuit of some sort, that does a few things:
                • Manages switching between AC adapter and battery power
                • Manages battery charging and generates power rail to charge battery


                There are 2 different designs to handle switching between AC adapter and battery power and feeding the system:
                • Hybrid power boost (HPB) and traditional circuits without power boost (see Warning in HPB section)
                • Narrow VDC (NVDC)

                Texas instrument has a nice overview of these technologies with some more details at https:...
                11-15-2020, 01:31 PM
              • kodox
                ThinkBook 15 G3 ACL Not Charging Battery - LA-K602P Board
                by kodox
                since i couldn't find schematic or boardview for this model (LA-K062P), i use closest board model found here https://www.badcaps.net/forum/troubl...-and-boardview

                the schematic share same marking for each component, using same PD-Controller, same BQ25710, the only different is the battery cell used. LA-K061P uses 3S battery while LA-K062P use 4S battery per schematic.
                what i've done:
                - flashing...
                12-29-2024, 02:49 AM
              • Shinju
                Razor Blade Steath 13" RZ09-01963 plugged in Not Charging (new battery)
                by Shinju
                Hey All!

                Long time forum member here with a problematic laptop issue!

                I got a RZ09-0196 with a bloated battery (still worked and charged fine) I pulled the old cell pack out and installed a new cell pack in its place.

                The laptop would not power on with the new battery installed without the power supply being plugged in.

                When booting into Win10 (all up to date BTW) I saw the battery icon with 49% plugged in not charging.

                TL;Dr version, old battery worked, charged but was bloated, installed a new non OEM replacement, laptop/windows...
                10-20-2021, 04:58 PM
              • Loading...
              • No more items.
              Working...